Description
Overview
Used Sanden SD7V16 air conditioning compressor (1270F) designed for PSA vehicles. This unit is a direct-fit replacement that restores reliable cooling performance to Citroën and Peugeot cabins, improving comfort for drivers and passengers. Key part numbers include 9655229080, 6453YW and 6453YX, making it easy to locate the exact fit for your vehicle.
Compatibility
Direct fit for Citroën C8 and Peugeot 807 with 2.0 HDi and 2.2 HDi engines. Also commonly referenced under PSA part numbers 9655229080, 6453YW and 6453YX. Always verify the part number against your vehicle VIN or the old compressor label before ordering.
Function And Benefits
The compressor is the heart of the air conditioning system: it compresses the refrigerant and circulates it through the system to remove heat from the passenger compartment. This Sanden SD7V16 model delivers efficient cooling, reduced cabin temperature, and predictable operation under normal service conditions. Choosing a correctly matched, tested compressor ensures faster recovery of full AC performance.
Installation & Replacement Notes
Intended for professional installation or experienced DIY mechanics. Standard replacement steps include: recover refrigerant with certified equipment, disconnect battery, remove drive belt, isolate and cap refrigerant lines, unbolt and remove the old compressor, install the replacement unit, replace any damaged O-rings, evacuate the system and recharge with the correct refrigerant and lubricant. Replace the receiver-drier/accumulator and perform a leak check for best long-term results. Follow manufacturer torque specs and service procedures for safe installation.
Common Failure Modes & Maintenance
Compressors typically fail due to worn bearings, clutch wear, internal contamination from system failures, or loss of lubrication. Regular AC system maintenance, timely replacement of the receiver-drier, and ensuring a clean, leak-free circuit extend compressor life. If you observe loud bearing noise, reduced cooling capacity, or clutch slipping, the compressor should be inspected and, if necessary, replaced to prevent further damage to the HVAC system.
Technical Information
- Manufacturer: Sanden
- Model: SD7V16 1270F
- Product Codes: 9655229080, 6453YW, 6453YX
- Other Numbers: Numbers Refer To Fitment For Citroën C8 And Peugeot 807 With 2.0 HDi And 2.2 HDi Engines
This compressor has been thoroughly tested and is supplied in good working condition. It represents a cost-effective solution for restoring the air conditioning performance of compatible PSA vehicles. For best results, have the system evacuated and recharged by an accredited workshop and replace associated service items as required.
